IEC 60079-0 Edition 8 was published in June 2026. As the foundation standard referenced by every Type of Protection in the IEC 60079 and 80079 series, these changes affect virtually every category of Ex-rated equipment.
CSA Group's technical team has completed a full clause-by-clause gap analysis between Edition 7 and Edition 8. In this webinar, we walk you through what has actually changed and what it means for your products and existing certificates.
Overview
IEC 60079-0 Edition 8 was published in June 2026. As the foundation standard referenced by the Types of Protection in the IEC 60079 and ISO 80079 series, Edition 8 may have implications across a wide range of Ex equipment.
Much of IEC 60079-0 Edition 8 clarifies existing requirements and practices. However, a focused set of changes may require closer review by manufacturers.
The challenge is determining:
- Which changes apply to your equipment?
- Could existing certification files require updates?
- Where might additional testing or documentation be required?
Understanding what has changed and what has not can help manufacturers determine the appropriate next steps for their products.
On November 17, CSA will be hosting for a 60-minute technical webinar examining the transition from Edition 7 to Edition 8.
During this 60-minute webinar, we will examine:
- Technical changes: Key areas introduced or revised in Edition 8 that may require manufacturer attention
- New and exiting products: Considerations for products being certified to Edition 8 and existing certified products
- Testing and documentation: Where existing test results may remain applicable and where further review may be required
Key Takeaways
- Discover the key technical changes requiring active manufacturer review
- Learn what has stayed the same and where prior test results remain valid
- Examine the two paths forward: new products certifying to Edition 8 and existing Edition 7 certificate updates
Speaker
Aaron Wagner, Technical Specialist for Hazardous Locations at CSA Group, brings almost 20 years of experience in compliance, standards, and engineering for hazardous locations across national and global markets.
Drawing on his extensive electrical engineering background, he has supported the oil & energy and food & beverage industries in delivering compliant products to customers and end users. His work is grounded in extensive knowledge of electrical codes and standards, with a focus on hazardous areas, including NFPA70 (NEC) Articles 500-506, ATEX, IECEx, and related frameworks.