Technical Articles
Thermometrics Corporation has published these technical articles:
(Temperature Sensing)
From this Article:
In a qualitative manner, we can describe the temperature of an object as that which determines the sensation of warmth or coldness felt from contact with it....
(Temperature Sensing)
From this Article:
The industry standard for platinum RTD's according to IEC-751 is + /- 0.12% (of resistance) at 0°C, commonly referred to as Class B accuracy. This will provide an accuracy of + /- 0.3°C at 0°C, which...
(Calibration and Testing Services)
From this Article:
Measurements shall be made on an apparatus suitable for the characteristic of the component to be measured as follows;
Ice point temperature resistance measurements may be taken using a digital...
(Temperature Sensing)
From this Article:
With these general guidelines to the basic function, performance, and recognized standards for RTD's, anyone can specify the right device for the application....
(Calibration and Testing Services)
From this Article:
How do you interpret a calibration report listing resistance ratio's and inverse differences? The resistance ratio is the ratio of the resistance of the thermometer at some temperature (t) to the...
(Signal Conditioning)
From this Article:
Which gives you the most accurate reading: A direct RTD signal into a controller or, an RTD signal converted to 4 to 20 mA via a transmitter and then fed into a controller?...
(Temperature Sensing)
From this Article:
We cannot make any generalizations, each application must be judged on its own. But if you have a new requirement for a temperature transducer, and you are not quite sure how to fill the space, run...
(Temperature Sensing)
From this Article:
List of common wire insulation and temperature limits...
(Temperature Sensing)
From this Article:
To aid in the selection of a sheath material a brief description of some of the properties of the more commonly used metals is linked below. The material selected must withstand the environmental...
(Temperature Sensing)
From this Article:
In 1983, the International Electrotechnical Commission (IEC) adopted the Deutsche Institute fur Normung (DIN) standard of platinum with a TC = 0.00385 ohm/ohm/°C....
(Temperature Sensing)
From this Article:
The following systems are dependent upon accurate temperature measurement....