Technical Articles
Endevco has published these technical articles:
(Wire and Cable)
From this Article:
I have a 10-32 coaxial cable connector that is damaged and unusable. Is there a connector replacement option?...
(Data Acquisition and Signal Conditioning)
From this Article:
How do I make use of the Shunt Calibration feature for the model 126?...
(Vibration and Acceleration Sensing)
From this Article:
This paper is written as an overview on low-noise piezoelectric accelerometers and will review when and where low-noise devices are needed as well as the engineering tradeoffs made during the design...
(Pressure Sensing)
From this Article:
I have received a pressure transducer with the calibration certificate. I am uncertain of the terms listed on the cal cert. Can you explain these terms a little more relative to how it may affect my...
(Vibration and Acceleration Sensing)
From this Article:
How do I select the correct gain based on my accelerometer model?...
(Vibration and Acceleration Sensing)
From this Article:
I am trying to use a Single Ended PE accelerometer, model 2248, as an input to the 6634C amplifier and there are no details in the instruction manual for this input....
(Data Acquisition and Signal Conditioning)
From this Article:
How can I translate the Error Code identified with a particular fault with my model 133 conditioner? Is there a definition of the particular error codes, since it is unclear what the error codes mean?...
(Wire and Cable)
From this Article:
Do you have connector assembly instructions for the 6917B cable with the replacement connector, 26574?...
(Pressure Sensing)
From this Article:
How is the ZMO value derived with Endevco absolute pressure transducers? I have an 8515C-50 transducer with a ZMO specified on the cal cert. Is this value recorded at atmospheric pressure?...