Computer Interface Transformer Test Equipment
from Tinsley Precision Instruments
The Tinsley 5896C is specifically designed to measure the resistance of highly inductive loads such as transformers, motors and generators. It has a measurement resolution of 0.01 µW for the 20 µW range and can measure resistances up to 6kW. Transformers up to 500 MVA and above can be... [See More]
- Features: Battery Powered; Computer Interface; Printer / Plotter Interface
- Test Parameters: DC Resistance
- Form Factor: Stand Alone / Bench
- Operating Humidity: 0.0 to 90
from OMICRON electronics Corp. USA
OMICRON's CT Analyzer is a unique lightweight instrument designed to meet the highest standards for performing excitation, ratio, polarity and winding resistance tests on current transformers (CTs) as well as burden-impedance measurement. [See More]
- Features: Computer Interface
- Form Factor: Stand Alone / Bench
- Phase: Three Phase
- Test Parameters: DC Resistance; Turn Ratio; Winding Polarity
from Tinsley Precision Instruments
An accurate mains/battery powered portable 100A Micro-Ohmmeter. Using the 4 terminal measurement technique the Tinsley 5897 gives basic accuracy of 0.2% and an overall resistance range of 0.1 µOhm to 40 Ohm. With an internal mains re-chargeable battery supply the Tinsley 5897 may be used "in... [See More]
- Features: Battery Powered; Computer Interface; Printer / Plotter Interface
- Test Parameters: DC Resistance
- Form Factor: Stand Alone / Bench
from OMICRON electronics Corp. USA
The most important aging indicator of transformers is the water content in the solid part of the insulation (paper, pressboard). An accurate knowledge about the actual moisture concentration is thus required in order to decide if further corrective action, such as on-site drying, is necessary. [See More]
- Features: Computer Interface
- Form Factor: Stand Alone / Bench
- Phase: SIngle Phase
- Test Parameters: Capacitance; Dielectric Response
from Tinsley Precision Instruments
Setting up the instrument is a simple case of typing in the vector group using the instrument front panel keypad and connecting to the offline transformer. All three phases are measured consecutively. with connecting and short circuit procedures at the primary and secondary voltage terminals... [See More]
- Features: Battery Powered; Computer Interface; Printer / Plotter Interface
- Form Factor: Portable
- Phase: Three Phase
- Test Parameters: Impedance Phase Angle; Turn Ratio; Deviance, Magnetising Current
from OMICRON electronics Corp. USA
The CMC 256plus is the universal solution for testing protection relays and calibrating electricity meters of up to class 0.2, transducers, power quality meters and synchrophasor measurement devices (IEEE C37.118). It is the right choice for all applications requiring the highest versatility and... [See More]
- Features: Computer Interface
- Form Factor: Stand Alone / Bench
- Phase: SIngle Phase
- Test Parameters: Relays
from OMICRON electronics Corp. USA
The CMC 356 is designed to optimally cover the modern requirements for commissioning and maintaining substations and protection devices. It opens up new possibilities especially for applications with 5 A CTs and for tests with very high power demand. [See More]
- Features: Computer Interface
- Form Factor: Stand Alone / Bench
- Phase: Three Phase
- Test Parameters: Relays