Sealer / Surface Sealant Architectural Coatings
from AGC Chemicals Americas, Inc.
AsahiGuard E-SERIES products are fluorinated water/oil repellents that contain no PFOA (at or above detection limits), longer chain PFCs or their precursors. Drawing on fluorine ’s extraordinary properties, these specialty chemicals provide excellent protection and durability against water,... [See More]
- Type: Coating; Sealer; Stain
- Features: Protective; Waterproof
- Form: Liquid
- Location / Orientation: Pavement / Walkway (optional feature)
from Fosroc Limited
Dekguard CP is a single component weather resistant impregnation and glaze, based on acrylic copolymer and siloxane. Dekguard CP combines an unique ability to protect against attacks by water, carbon dioxide (CO2) and other chemicals, with an ability to allow water vapour to escape from the... [See More]
- Type: Coating; Sealer
- Location / Orientation: Floor
from Columbia Chemical Corporation
Lac-Chro-SEAL ® is a non-hazardous lacquer coating for enhanced corrosion resistance on electroplated deposits and base metals. It air dries quickly to a very thin, clear & glossy finish which prevents fingerprints and provides significant protection to high humidity conditions. [See More]
- Type: Coating; Clear Coat; Sealer; Lacquer
- Substrate: Metallic; Other; Zinc & Zinc Alloy Deposits Over Steel
- Cure / Setting Technology: Film Drying
- Coating Material: Acrylic; Zinc; Water
from Sherwin-Williams Protective & Marine Coatings
ArmorSeal ®33 EPOXY PRIMER/SEALER is a low viscosity, 100% solids, high build, fast cure, epoxy primer designed for use under ArmorSeal ®650 or where a high build primer is needed. This primer/sealer enhances adhesion by penetrating into the concrete substrate and helps reduce bubbling and... [See More]
- Type: Coating; Primer; Sealer
- Substrate: Concrete; Wood
- Cure / Setting Technology: Multicomponent
- Coating Material: Epoxy; Resin
from Wacker Chemical Corp.
ELASTOSIL ® E91 is a self-levelling silicone rubber with very good mechanical properties, which cures at room temperature under the influence of atmospheric moisture. It can also be cured in steam oven within 3 min. Properties. fast curing in steam oven. high elongation properties. acetic... [See More]
- Type: Coating; Sealer
- Substrate: Other; Textiles
- Cure / Setting Technology: Reactive or Moisture Cured
- Coating Material: Resin; Rubber; Silicone
from Aremco Products, Inc.
Aremco offers an expansive range of ceramic-based materials used for the assembly of high temperature, high power electrical devices, and high temperature fixtures, molds and tooling. These materials, based on aluminum oxide, aluminum nitride, magnesium oxide, silicon dioxide, silicon carbide,... [See More]
- Type: Coating (optional feature); Sealer
- Coating Material: Metal Filled; Resin
- Substrate: Glass
- Operating Temperature: 2000
from KOSTER American Corporation
KOSTER Elastic Roof is an elastic, crack bridging, and solvent-free waterproofing material for dry and slightly damp substrates. It is free of VOC's (Volatile Organic Compounds), free of Polyurethanes, and free of Isocyanates. The fast drying foil-like coating is highly flexible, watertight and... [See More]
- Type: Coating (optional feature); Sealer
- Location / Orientation: Roof
from Sanchem, Inc.
Enhances paint and coating adhesion specifically from filiform corrosion on aluminum castings such as (380, 383, 360, aluminum zinc die castings [See More]
- Type: Sealer
- Substrate: Aluminum; Steel; Other; Magnesium
- Cure / Setting Technology: Film Drying
- Coating Material: Chromate-Free
from Rust-Oleum Corporation
Heavy duty static control floor topping, 3 component epoxy resin polymer [See More]
- Type: Coating; Clear Coat; Sealer
- Substrate: Concrete
- Cure / Setting Technology: Multicomponent
- Coating Material: Epoxy; Resin
from Sherwin-Williams
Paint & Coatings. A wide variety of coatings for residential or commercial use offer top quality performance. Primers. Exterior primers assure superior hiding, topcoat appearance and long-lasting results. Commercial High-Performance Coatings. A comprehensive line-up of high-performance coatings... [See More]
- Type: Coating; Paint; Enamel; Primer; Base Coat; Clear Coat; Sealer; Stain
- Substrate: Concrete; Metallic; Plastic; Wood
- Cure / Setting Technology: Film Drying
- Coating Material: Acrylic; Alkyd; Resin
from ADSIL Inc.
Effective barrier facilitates easy removal of most common forms of graffiti [See More]
- Type: Coating; Clear Coat; Sealer
- Substrate: Aluminum; Ceramic; Concrete; Metallic
- Cure / Setting Technology: Film Drying
- Coating Material: Inorganic (Silicate, Cement, Glaze); Inorganic Siloxane
from Fosroc Limited
Nitocote EP403 is a two pack, solvent free, epoxy resin material. It is supplied in pre-measured quantities ready for site mixing and use. The material cures to provide a smooth, tough and resistant finish. It is available in light grey. [See More]
- Type: Coating; Sealer
- Location / Orientation: Floor
from Columbia Chemical Corporation
Zinc-Chro-SHIELD ® is a unique sealer for chromated zinc deposits which dramatically increases corrosion protection at very little additional cost. And since it's added to the final stagnant rinse at low concentrations (1% to 8% by volume), no additional equipment is required. Zinc-Chro-SHIELD... [See More]
- Type: Coating; Sealer
- Substrate: Steel; Other; Zinc & Zinc Alloy Deposits Over Steel
- Cure / Setting Technology: Film Drying
- Coating Material: Zinc; Water; Silicate Based
from Sherwin-Williams Protective & Marine Coatings
CUI is one of the costliest problems facing the hydrocarbon processing environment today. Infiltration by outside moisture or from the process environment through seams, gaps or other discontinuities in steel under insulation can lead to major equipment outages. Whether from periodic inspection and... [See More]
- Type: Coating; Sealer; Coating Under Insulation
- Substrate: Metallic
- Cure / Setting Technology: Film Drying
- Coating Material: Resin; Multi-Polymetric
from KOSTER American Corporation
KOSTER EM-VS is a universally applicable, water based, scratch-resistant epoxy resin sealant with very high covering power. It bonds very well to all cementitious substrates. It is resistant to medium mechanical stresses and to short term chemical stresses caused by contacts with diluted acids,... [See More]
- Type: Sealer
- Location / Orientation: Floor
from Rust-Oleum Corporation
Clear, unpigmented, two component, zero VOC waterborne epoxy primer. [See More]
- Type: Coating; Primer; Sealer
- Substrate: Concrete
- Cure / Setting Technology: Multicomponent
- Coating Material: Epoxy; Resin
from Sherwin-Williams
Paint & Coatings. A wide variety of coatings for residential or commercial use offer top quality performance. Primers. Exterior primers assure superior hiding, topcoat appearance and long-lasting results. Commercial High-Performance Coatings. A comprehensive line-up of high-performance coatings... [See More]
- Type: Coating; Paint; Enamel; Primer; Base Coat; Clear Coat; Sealer; Stain
- Substrate: Concrete; Metallic; Plastic; Wood
- Cure / Setting Technology: Film Drying
- Coating Material: Acrylic; Alkyd; Resin
from Sherwin-Williams Protective & Marine Coatings
The movement to produce, liquefy, store and transfer natural gas at sea brings to the forefront a new concern in the risk assessment stages of any floating liquefied natural gas (FLNG) project: how to protect the vessel and support structures from the catastrophic effects of a cryogenic LNG spill on... [See More]
- Type: Coating; Sealer
- Substrate: Metallic
- Cure / Setting Technology: Film Drying
- Coating Material: Epoxy; Resin
from Sherwin-Williams
Paint & Coatings. A wide variety of coatings for residential or commercial use offer top quality performance. Primers. Interior primers assure superior hiding, topcoat appearance and long-lasting results. Wood Stains, Sealers & Clear Topcoats. A wide variety of stains and sealers for... [See More]
- Type: Coating; Paint; Enamel; Primer; Base Coat; Clear Coat; Sealer; Stain
- Substrate: Concrete; Metallic; Plastic; Wood
- Cure / Setting Technology: Film Drying
- Coating Material: Acrylic; Alkyd; Resin
from Sherwin-Williams Protective & Marine Coatings
Hydrocarbon fires can reach excessively high temperatures in a matter of minutes — or less. Structural steel under load can lose 20 percent of its yield strength at 950 F (500 C), and over half of its integrity at 1100 F (593 C). A near-total depletion of strength quickly follows at 2200 F... [See More]
- Type: Coating; Sealer
- Features: Flame Retardant / UL 94V-0 Rated; Heat Resistant; Protective; Fire-Proofing
- Substrate: Metallic
- Location / Orientation: Exterior
from Sherwin-Williams
Paint & Coatings. A wide variety of coatings for residential or commercial use offer top quality performance. Primers. Interior primers assure superior hiding, topcoat appearance and long-lasting results. Wood Stains, Sealers & Clear Topcoats. A wide variety of stains and sealers for... [See More]
- Type: Coating; Paint; Enamel; Primer; Base Coat; Clear Coat; Sealer; Stain
- Substrate: Concrete; Metallic; Plastic; Wood
- Cure / Setting Technology: Film Drying
- Coating Material: Acrylic; Alkyd; Resin